Cub-cadet GT-3100 Manuel d'utilisateur

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLYWarning: This unit is equipped with an internal combustion engine and should not be used on orn

10SECTION 5: SAFETY LABELS FOUND ON YOUR UNITFigure 2 TO ENSURE SAFE AND PROPER OPERATIONOF TRANSMISSION,ONLY USE CUB CADETDRIVE SYSTEM FLUID PLUS.73

11ACFGHEPKIMNORTSJB(Not Shown)QABCDEFGHIKLMNOPQRLow Fuel Indicator LampIndicator Panel/Hour MeterKey Switch ModuleParking Brake LeverPTO SwitchBrake P

12NOTE: References to LEFT andRIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates

13• The hour meter is activated whenthe key switch is turned to either the“NORMAL MOWING” or the"REVERSE CAUTION MODE"switch positions. A re

14D. Parking Brake LeverFigure 6 The parking brake lever is located tothe right of the steering wheel in thedash panel. With the brake pedaldepressed

15L. Transmission Oil Fill/DipstickThe transmission oil fill/dipstick islocated at the back of the tractor in therear draw bar. The handle of thetrans

16SECTION 7: OPERATIONSafety Interlock SwitchesThis tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interl

17Starting The Engine• Operator must be sitting in thetractor seat.• Push choke lever to the full chokeposition. Less choking may benecessary due to v

18• If properly engaged, the cruise leverand forward control pedal shouldlock in the down position, and thetractor will maintain the sameforward speed

19Using the REVERSE CAUTION MODE key positionThe REVERSE CAUTION MODEposition of the key switch module allowsthe machine to be operated in reversewith

2NOTES

20Using The DrawbarDrawbar equipment must be hitched tothe tractor only at the hitch hole. SeeFigure 13.Figure 13 MowingWARNING: To avoid possi-ble

21SECTION 8: ADJUSTMENTSSeat AdjustmentWARNING: Do not adjustthe seat when the tractor ismoving, as this could causethe operator to lose controlof t

22Brake Inspection and AdjustmentDuring normal operation, the tractorbrake is subject to minimal wear. How-ever, the brake should be periodicallyteste

23SECTION 9: MAINTENANCEMaintenance Chart‡ Change oil and filter after first 5 hours† More often under dusty conditions†† Clean every 25 hours or more

24LUBRICATION ILLUSTRATIONCub Cadet 251H EP Greaseor equivalent No. 2 lithium greaseEngine Oil: See Figure 27 on page 34Transmission Oil - Cub Cadet D

25Accessing Engine CompartmentThe engine compartment can beaccessed by raising the hood asfollows:• Lift the hood straight upward at therecessed notch

26with a solution of ammonia/water orbaking soda/water.• NEVER connect (or disconnect)battery charger clips to the batterywhile the charger is turned

27Charging the BatteryTest and, if necessary, recharge thebattery after the tractor has beenstored for a period of time.• A voltmeter or load tester s

28then fully reinserted before beingwithdrawn again for a true reading.Figure 21 Adding Transmission OilWARNING: The fluid for yourtransmission has b

29Figure 22 • Clean around the base of the trans-mission oil filter and remove thefilter by turning it counterclockwise.• Apply a light coating of cl

3TABLE OF CONTENTSPAGETRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4IMPORTANT SAFE OPERATION PRAC

30FuseFuses are installed to protect the trac-tor’s electrical system from damagecaused by excessive amperage.Always use the same capacity fuse forrep

31SECTION 10: ENGINE INFORMATIONKOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD EQUIPMENT ENGINESThe U.S. Envi

32LIMITATIONSThis Emission Control System Warranty shall not cover any of the following:(a) repair or replacement required because of misuse or neglec

33Cleaning The EngineThis tractor has an air-cooled engine.Air must be able to circulate freelyaround the engine through theflywheel screen, through t

34Refer to Figure 27 for informationregarding the proper type of oil to addto the crankcase.• Place the tractor on a level surfaceand engage the parki

35• Attach the flexible tubing to thedrain valve. Place an appropriatecontainer below the open end of thetubing to collect the old oil.• To open the d

36WARNING: Operating theengine with loose or dam-aged air cleaner componentswill allow unfiltered air intothe carburetor, causing ex-tensive wear and

37SECTION 11: TROUBLE SHOOTINGPossible Cause Possible RemedyHard To StartNo fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel li

38Fuel tank air vent clogged Remove obstruction from the vent in the fuel tank cap.Air leakage between carburetor and engine Remove air cleaner. Tight

39SECTION 12: OPTIONAL EQUIPMENTWhen you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. Howeve

4SECTION 1: TRACTOR PREPARATIONConnect the BatteryBattery posts, terminals andrelated accessories containlead and lead compounds.Wash hands after hand

40SECTION 13: SPECIFICATIONSEngineManufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower .

41SECTION 14: SLOPE GAUGEWARNING: Do not mow on inclines with a slope in excess of 15degrees (a rise of approximately 2-1/2 feet every 10 feet). A ri

42

43CUB CADET LLCMANUFACTURER’S ONE YEAR LIMITED WARRANTY(COMMERCIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)wit

44No implied warranty, including any implied warranty of merchantability orfitness for a particular purpose, applies after the applicable period ofexp

45CUB CADET LLCMANUFACTURER’S LIMITED WARRANTY(RESIDENTIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respec

46b. CUB CADET does not extend any warranty for products sold or exportedoutside of the United States of America, its possessions and territories,exce

47

SECTION 15: QUICK REFERENCE PARTSDescription Part NumberEngine Oil 737-3030A (10W30)737-3049 (5W30)Air Filter KH-47-083-03KH-24-083-02Engine Oil Fil

5SECTION 2: IMPORTANT SAFE OPERATION PRACTICESWARNING: THIS SYMBOL POINTS OUT IMPORTANT SAFETYINSTRUCTIONS WHICH, IF NOT FOLLOWED, COULD ENDANGERTHE P

6• Never leave a running machineunattended. Always turn off blade(s),place transmission in neutral, setpark brake, stop engine and removekey before di

7• Avoid starting or stopping on aslope. If tires lose traction, disen-gage the blade(s) and proceedslowly straight down the slope.• Follow the manufa

8• To reduce fire hazard, keep themachine free of grass, leaves orother debris build-up. Clean up oil orfuel spillage. Allow machine to coolat least 5

9SECTION 3: CALLING SERVICE INFORMATIONThe engine manufacturer is responsible for all engine-related issues withregards to performance, power-rating,